GMCforum: GMCnet » Awning Removal

Home » Public Forums » GMCnet » Awning Removal

Show: Today's Messages :: Polls :: Message Navigator

Awning Removal [message #316608]

Tue, 25 April 2017 16:28

pnbarber

Messages: 11
Registered: June 2016
Location: Raleigh, NC

Karma: 0

Junior Member

We are preparing our coach for painting this spring and I need to remove the Zip Dee awning. I assume I have to unload the spring before removal of the entire awning and metal cover attached to the top of the coach but if there is a way to remove it intact that would be great.

P. Barber Raleigh, NC 1978 GMC Royale - 1995 Clasco Upgrade

Report message to a moderator

Re: [GMCnet] Awning Removal [message #316611 is a reply to message #316608]

Tue, 25 April 2017 17:05

James Hupy

Messages: 6806
Registered: May 2010

Karma: -62

Senior Member

Yes, you need to unwind the spring. It has about 10 turns of preload. Only
one end is attached to the spring. The other end is just a short axle. I
deploy the awning to parade position or far enough that the end support arm
when disassembled from the bottom of the coach can be separated from the
upper solid bar. DO NOT UNBOLT THE END PIECE UNTIL THE SPRING IS UNWOUND.
YOU CAN BE INJURED IF YOU DO. IF you want specific instructions on how to
do this, contact Zip-Dee or Applied GMC.
If the awning has been in place for a long time, the dirt and crud in the
aluminum cover will make removal a difficult task. Be sure to scrub and
rinse the cover and the roof rail. On 26 foot coaches, the clearance light
on the passenger side rear might present a problem when you go to remove
the awning assembly from the coach. Proceed carefully and wear protective
gloves.
Jim Hupy
Salem, Or
78 GMC ROYALE 403

On Apr 25, 2017 2:28 PM, "Perry Barber" wrote:

> We are preparing our coach for painting this spring and I need to remove
> the Zip Dee awning. I assume I have to unload the spring before removal of
> the entire awning and metal cover attached to the top of the coach but if
> there is a way to remove it intact that would be great.
>
>
> --
> P. Barber
> Raleigh, NC
> 1978 GMC Royale - 1995 Clasco Upgrade
>
> _______________________________________________
> GMCnet mailing list
> Unsubscribe or Change List Options:
> http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
>
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org

Report message to a moderator

Re: [GMCnet] Awning Removal [message #316613 is a reply to message #316608]

Tue, 25 April 2017 17:13

Emery Stora

Messages: 959
Registered: January 2011

Karma: 4

Senior Member

Perry
I am sending the Zipdee instructions for installing it to the GMC. You can easily tell how to uninstall it by reading the instructions.

Emery Stora
77 Kingsley
Frederick, CO

> On Apr 25, 2017, at 3:28 PM, Perry Barber wrote:
>
> We are preparing our coach for painting this spring and I need to remove the Zip Dee awning. I assume I have to unload the spring before removal of
> the entire awning and metal cover attached to the top of the coach but if there is a way to remove it intact that would be great.
>
>
> --
> P. Barber
> Raleigh, NC
> 1978 GMC Royale - 1995 Clasco Upgrade
>
> _______________________________________________
> GMCnet mailing list
> Unsubscribe or Change List Options:
> http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org

_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org

Report message to a moderator

Re: Awning Removal [message #316634 is a reply to message #316608]

Wed, 26 April 2017 08:38

pnbarber

Messages: 11
Registered: June 2016
Location: Raleigh, NC

Karma: 0

Junior Member

Thanks to all that replied. With this kind of help, it makes owning a GMC easier and in this case, less dangerous.

P. Barber Raleigh, NC 1978 GMC Royale - 1995 Clasco Upgrade

Report message to a moderator

Previous Topic:	Seat belts
Next Topic:	[GMCnet] Were can I get a Royale LP gauge that goes in the control panel.

Goto Forum:

-=] Back to Top [=-

Current Time: Sat Nov 16 05:26:31 CST 2024

Total time taken to generate the page: 0.01327 seconds