Found the probable cause of my cockpit gas smell [message #267359] |
Tue, 09 December 2014 13:52 |
kerry pinkerton
Messages: 2565 Registered: July 2012 Location: Harvest, Al
Karma: 15
|
Senior Member |
|
|
This time I think I really did. I've looked EVERYFRICKINGWHERE for the source of this gas smell for nearly 2 years now. Was about ready to drop the tanks because I'd looked every else multiple times. Just yesterday, I ran the gas lines from the cross member all the way to the tanks. Nothing. Dry as a bone.
Today, I was standing on my head in the hatch checking the timing and just happened to see something shiny move. Pulled out my little pocket flashlight and looked closer and saw a drop of gas run down the gas line.
Early last year I purchased one of Jim B's insulated gas lines. It has male flair fittings on each end. I wanted to connect to the steel line from the gas tanks with a short rubber hose (I run electric fuel pumps). So I had a short length of 3/8 brake line with the male flair fitting so I connected the two of them together with a female/female flair fitting. Apparently I did not get one tight enough and it weeped just a bit. It doesn't take much gas to stink things up. Fortunately it was right behind the radiator so the air from the fan evaporated it before it got back to the manifold or things could have been unpleasant.
Pretty sure this is the problem. It certainly was "A" problem. The electric pumps have check valves that would keep pressure in the hose so it would weep for a long time when not running. This fits with our noticing the smell every time we walked past the coach even when it had not been started in a month. The location was somewhere that you would never see it unless you were WAAAAY up at the front of the engine standing on your head.
Note, this had nothing to do with Jim B's fuel line. It had to do with me not tightening it correctly. If I recall correctly, I did it on the coach instead of taking it loose at the carb and doing it right.
Kerry Pinkerton - North Alabama
Had 5 over the years. Currently have a '06 Fleetwood Discovery 39L
|
|
|
Re: Found the probable cause of my cockpit gas smell [message #267401 is a reply to message #267359] |
Wed, 10 December 2014 13:44 |
George Beckman
Messages: 1085 Registered: October 2008 Location: Colfax, CA
Karma: 11
|
Senior Member |
|
|
kerry pinkerton wrote on Tue, 09 December 2014 11:52This time I think I really did. I've looked EVERYFRICKINGWHERE for the source of this gas smell for nearly 2 years now. Was about ready to drop the tanks because I'd looked every else multiple times. Just yesterday, I ran the gas lines from the cross member all the way to the tanks. Nothing. Dry as a bone.
t.
Ruth says, how many brain cells did you loose in the two years from smelling gas. Ha!
'74 Eleganza, SE, Howell + EBL
Best Wishes,
George
|
|
|
|
Re: Found the probable cause of my cockpit gas smell [message #268146 is a reply to message #267359] |
Wed, 24 December 2014 08:12 |
kerry pinkerton
Messages: 2565 Registered: July 2012 Location: Harvest, Al
Karma: 15
|
Senior Member |
|
|
After a few weeks and a couple drives, I can now state that the TINY dribble of gas from the line WAS the cause of the gas smell in the cockpit. No more gas smell at all.
Kerry Pinkerton - North Alabama
Had 5 over the years. Currently have a '06 Fleetwood Discovery 39L
|
|
|
|
Re: Found the probable cause of my cockpit gas smell [message #268194 is a reply to message #268178] |
Wed, 24 December 2014 19:47 |
Carl S.
Messages: 4186 Registered: January 2009 Location: Tucson, AZ.
Karma: 13
|
Senior Member |
|
|
Chris Tyler wrote on Wed, 24 December 2014 15:22My Girlfriend Lee complains of gas smells when we have the coach out. But I think we are talking about a different problem.
I often blame the dog.
LOL
Carl Stouffer
'75 ex Palm Beach
Tucson, AZ.
Chuck Aulgur Reaction Arm Disc Brakes, Quadrabags, 3.70 LSD final drive, Lenzi knuckles/hubs, Dodge Truck 16" X 8" front wheels, Rear American Eagles, Solar battery charging. GMCSJ and GMCMI member
|
|
|
|