[GMCnet] Small white wires Out of the Owen. HELP [message #217885] |
Sun, 11 August 2013 20:50 |
BobDunahugh
Messages: 2465 Registered: October 2010 Location: Cedar Rapids, IA
Karma: 11
|
Senior Member |
|
|
Pulled the tanks out of the Royale. Moved the generator fuel line from the tee in main tank line to the gen port that is in the main tank. Then I came across lots, and lots of wire butt connectors. And they put lots of different colored wires in. With no thought of color matching. All wrapped up in an electrical tape that I had never run into when working with wires. It was vary sticky, and SILVER. YES, Duct tape. And if that wasn't enough. All 4 white wires that are coming down out of the gen. They were all pulled off of the colored wires. Now what?Can someone lead me home with this.Member GMCMI Bob Dunahugh
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
|
|
|
|
Re: [GMCnet] Small white wires Out of the Owen. HELP [message #217903 is a reply to message #217885] |
Sun, 11 August 2013 22:19 |
Dennis S
Messages: 3046 Registered: November 2005
Karma: 2
|
Senior Member |
|
|
Bob,
In this Onan rebuild manual are wiring diagrams...
http://www.bdub.net/manuals/Onan/Onan6kwNH_Major-Service.pdf
You will note that there are four wires to the remote start button -- but s little more information or a picture would be very helpful in directling your efforts.
Dennis
BobDunahugh wrote on Sun, 11 August 2013 20:50 | Pulled the tanks out of the Royale. Moved the generator fuel line from the tee in main tank line to the gen port that is in the main tank. Then I came across lots, and lots of wire butt connectors. And they put lots of different colored wires in. With no thought of color matching. All wrapped up in an electrical tape that I had never run into when working with wires. It was vary sticky, and SILVER. YES, Duct tape. And if that wasn't enough. All 4 white wires that are coming down out of the gen. They were all pulled off of the colored wires. Now what?Can someone lead me home with this.Member GMCMI Bob Dunahugh
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
|
Dennis S
73 Painted Desert 230
Memphis TN Metro
|
|
|
Re: [GMCnet] Small white wires Out of the Owen. HELP [message #217905 is a reply to message #217889] |
Sun, 11 August 2013 22:23 |
Mike Teets
Messages: 299 Registered: January 2004 Location: Dublin, OH
Karma: 0
|
Senior Member |
|
|
There are 4 wires that go from the control board to the remote Onan panel
inside the coach.
On Sun, Aug 11, 2013 at 10:13 PM, A. <markbb1@netzero.com> wrote:
>
>
> BobDunahugh wrote on Sun, 11 August 2013 20:50
> > Pulled the tanks out of the Royale. Moved the generator fuel line from
> the tee in main tank line to the gen port that is in the main tank. Then I
> came across lots, and lots of wire butt connectors. And they put lots of
> different colored wires in. With no thought of color matching. All wrapped
> up in an electrical tape that I had never run into when working with wires.
> It was vary sticky, and SILVER. YES, Duct tape. And if that wasn't enough.
> All 4 white wires that are coming down out of the gen. They were all pulled
> off of the colored wires. Now what?Can someone lead me home with
> this.Member GMCMI Bob Dunahugh
> Bob,
>
> Download the appropriate wiring diagram for your year/model from here and
> see if what you found matches up with anything OEM.
>
> http://www.bdub.net/wirediagrams/
> --
> '73 23' Sequoia For Camping
> '73 23' CanyonLands For Sale
> UA (Upper Alabama)
> "Time is money. If you use YOUR time, you get to keep YOUR money."
> _______________________________________________
> GMCnet mailing list
> Unsubscribe or Change List Options:
> http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
>
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
Mike, GMCing since 2002
77 Palm Beach, 260, 403
Dublin, OH
http://teamteets.com/gmc/
|
|
|
|
Re: [GMCnet] Small white wires Out of the Owen. HELP [message #217953 is a reply to message #217936] |
Mon, 12 August 2013 08:28 |
|
USAussie
Messages: 15912 Registered: July 2007 Location: Sydney, Australia
Karma: 6
|
Senior Member |
|
|
Bob,
I have sent you an off net email that should help solve your problem.
Regards,
Rob M.
-----Original Message-----
From: Bob Dunahugh
I do understand that the 4 white wires that are coming down out of the gen go to the remote inside the coach. And there are 4
colored wires that come out of the remote panel, and go to the gen in the rear. The white wires were all pulled off of the colored
wires. And the manual doesn't talk about colors. From the remote I have a white, red, green, and blue. And thanks for the
manual.Member GMCMI Bob
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
Regards,
Rob M. (USAussie)
The Pedantic Mechanic
Sydney, Australia
'75 Avion - AUS - The Blue Streak TZE365V100428
'75 Avion - USA - Double Trouble TZE365V100426
|
|
|
Re: [GMCnet] Small white wires Out of the Owen. HELP [message #217957 is a reply to message #217936] |
Mon, 12 August 2013 08:36 |
powerjon
Messages: 2446 Registered: January 2004
Karma: 5
|
Senior Member |
|
|
Bob,
The wires from the remote panel go to a connector that is located just behind the onan near the frame. This connector is typically corroded and causes many problems including not starting, not being able to stop and sometime causing the onan starter to be stuck on after starting the onan. If you look here your will see where the colors change most of the time. A lot of owner have cut this plug and butt spliced the wires back together one at a time as to not miss wire. This is one of these "Been there and done that" problems. You have to jack the coach to get under the coach, but sure to be safe and put stands under the coach.
JR Wright
78 Buskirk Stretch
75 Avion
Michigan
On Aug 12, 2013, at 2:55 AM, Bob Dunahugh <yenko108@hotmail.com> wrote:
>
> I do understand that the 4 white wires that are coming down out of the gen go to the remote inside the coach. And there are 4 colored wires that come out of the remote panel, and go to the gen in the rear. The white wires were all pulled off of the colored wires. And the manual doesn't talk about colors. From the remote I have a white, red, green, and blue. And thanks for the manual.Member GMCMI Bob Dunahugh
>
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
J.R. Wright
GMC GreatLaker
GMC Eastern States
GMCMI
78 30' Buskirk Stretch
75 Avion Under Reconstruction
Michigan
|
|
|
Re: [GMCnet] Small white wires Out of the Owen. HELP [message #217966 is a reply to message #217885] |
Mon, 12 August 2013 09:04 |
Emery Stora
Messages: 959 Registered: January 2011
Karma: 4
|
Senior Member |
|
|
You found one of the joys? of owning a Royale. If it had been GM built the color of the wires would have been consistant from the Onan to the inside control panel, but Coachmen apparently used whatever color wire they had on hand and it varied from coach to coach.
What you have to do, if you have the wiring diagram, is to get a long jumper wire and , using an alligator clip to connect to a wire at the control panel end, pull the jumper through your rear window and check for continuity at the end where the wires were taped up. Slide a piece of heat shrink tubing onto the wire and solder it to the proper wire leading to the Onan. Repeat for the other wires.
Emery Stora
On Aug 11, 2013, at 7:50 PM, Bob Dunahugh <yenko108@hotmail.com> wrote:
> Pulled the tanks out of the Royale. Moved the generator fuel line from the tee in main tank line to the gen port that is in the main tank. Then I came across lots, and lots of wire butt connectors. And they put lots of different colored wires in. With no thought of color matching. All wrapped up in an electrical tape that I had never run into when working with wires. It was vary sticky, and SILVER. YES, Duct tape. And if that wasn't enough. All 4 white wires that are coming down out of the gen. They were all pulled off of the colored wires. Now what?Can someone lead me home with this.Member GMCMI Bob Dunahugh
>
>
> _______________________________________________
> GMCnet mailing list
> Unsubscribe or Change List Options:
> http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
|
|
|
[GMCnet] Small white wires Out of the Owen. HELP [message #218096 is a reply to message #217936] |
Tue, 13 August 2013 01:45 |
BobDunahugh
Messages: 2465 Registered: October 2010 Location: Cedar Rapids, IA
Karma: 11
|
Senior Member |
|
|
Thanks to all that responded. The two 78 Royales that I have here, have 54 VIN's between them. Emery was right on. Yes, Coachman seems to have had a lot of white wire on hand at the time these two couch's were built. I'm going to have to work the wiring out in the way Emery talked about.Trying to get all the lose ends tied up this week. I can say that this coach has all most nothing to stop it along the way. Looked at the water system today. Everything so far works. But the water heater is original. So I ordered a new one from Jim K this afternoon. Not going to take a chance of a water leak. Bob Dunahugh Member GMCMI
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
|
|
|