Home » Public Forums » GMCnet » Brakes and brake fluid
Re: [GMCnet] Brakes and brake fluid [message #64274 is a reply to message #64267] |
Sat, 14 November 2009 18:29 |
GMC_LES
Messages: 569 Registered: October 2009 Location: Montreal
Karma:
|
Senior Member |
|
|
Rob,
The very first car in my fleet to receive the DOT 5 was my father's Audi
5000. We did a 5 minute flush using the DOT 5 and the pedal pump bleeding
procedure, unaware of the fact that DOT 5 is bad for creating & holding air
bubbles. We got a mediocre pedal initially but it got better after a few
days. We eventually did a second bleeding procedure several weeks later with
a pressure bleeder and the car ran for many years like that without any
problems. The brake system was not dismantled and cleaned, The lines were
not flushed, and the hydraulic components had been in service since the car
was new. I certainly would not do that now with the knowledge I have gained,
but the car didn't suffer any from the way in which we did the conversion.
This was the car in which we noticed the improvement in rear brake
sensitivity during severe cold operation (-20 and colder) We had done the
conversion over Xmas so we had a good feel of the before and after with no
other changes to the braking system.
During a lengthy discussion with the engineer at Cartel many years ago, I
asked about what happens to the two fluids when mixed together. The engineer
said that the old fluid would just puddle in the lowest points of the system
and be somewhat harmless other than to hold moisture and potentially cause
corrosion at those points. The two fluids would not intermix. He said that
the best method was always to do a thorough cleaning and refurbish of the
hydraulic system prior to using DOT 5 silicone fluid.
If you wanted to just dump the old fluid and add DOT 5 without dis-assembly
& cleaning, the engineer recommended a thorough flush of the system first
using fresh, clean DOT 4. This ensured that whatever DOT 4 fluid remaining
in the system after a DOT 5 conversion would contain a very low moisture
content and be relatively harmless.
Les Burt
Montreal
-----Original Message-----
From: gmclist-bounces@temp.gmcnet.org
[mailto:gmclist-bounces@temp.gmcnet.org] On Behalf Of Rob Mueller
Sent: November 14, 2009 6:55 PM
To: gmclist@temp.gmcnet.org
Subject: Re: [GMCnet] Brakes and brake fluid
Les,
Wow that's an impressive service history!
Do you agree with Cartel's statement:
Simple changeover - just perform normal "brake bleeding job"
Regards,
Rob Mueller
Sydney, Australia
AUS '75 Avion-The Blue Streak TZE365V100428
USA '75 Avion-Double Trouble TZE365V100426
-----Original Message-----
From: gmclist-bounces@temp.gmcnet.org
[mailto:gmclist-bounces@temp.gmcnet.org] On Behalf Of Les Burt
Sent: Sunday, 15 November 2009 10:49 AM
To: gmclist@temp.gmcnet.org
Subject: Re: [GMCnet] Brakes and brake fluid
I have been using Cartel DOT 5 silicone fluid for almost 20 years.
http://www.cartelproducts.com/performancebrakefluids/siliconebrakefluiddot5.
html
http://tinyurl.com/ygbgpta
Les Burt
Montreal
_______________________________________________
GMCnet mailing list
List Information and Subscription Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
_______________________________________________
GMCnet mailing list
List Information and Subscription Options:
http://temp.gmcnet.org/cgi-bin/mailman/listinfo/gmclist
Les Burt
Montreal
1975 Eleganza 26ft
A work in Progress
|
|
|
|
|
Brakes and brake fluid
By: Harry on Fri, 13 November 2009 15:16
|
|
|
Re: [GMCnet] Brakes and brake fluid
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: USAussie on Sat, 14 November 2009 13:57
|
|
|
Re: [GMCnet] Brakes and brake fluid
|
|
|
Re: Brakes and brake fluid
By: JohnL455 on Sat, 14 November 2009 15:49
|
|
|
Re: Brakes and brake fluid
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: GMC_LES on Sat, 14 November 2009 17:48
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: USAussie on Sat, 14 November 2009 17:55
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: GMC_LES on Sat, 14 November 2009 18:29
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: GMC_LES on Sat, 14 November 2009 18:36
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: USAussie on Sat, 14 November 2009 19:26
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: Harry on Sat, 14 November 2009 19:44
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: GMC_LES on Sat, 14 November 2009 21:35
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: roy1 on Sat, 14 November 2009 18:55
|
|
|
Re: [GMCnet] Brakes and brake fluid
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: USAussie on Sun, 15 November 2009 07:03
|
|
|
Re: [GMCnet] Brakes and brake fluid
By: midlf on Sun, 15 November 2009 07:55
|
|
|
Re: [GMCnet] Brakes and brake fluid
|
|
|
[GMCnet] Timing chain
|
|
|
Re: [GMCnet] Timing chain
|
|
|
Re: [GMCnet] Timing chain
|
|
|
Re: [GMCnet] Timing chain
|
|
|
Re: [GMCnet] Timing chain
By: Charles on Sun, 15 November 2009 08:57
|
|
|
Re: [GMCnet] Timing chain
By: USAussie on Sun, 15 November 2009 06:35
|
|
|
Re: Brakes and brake fluid
|
|
|
Re: Brakes and brake fluid
|
Goto Forum:
Current Time: Sat Sep 28 16:42:27 CDT 2024
Total time taken to generate the page: 0.01596 seconds
|