Home » Public Forums » GMCnet » [GMCnet] Onan, tracking fuel problems
[GMCnet] Onan, tracking fuel problems [message #325015] |
Mon, 16 October 2017 18:01 |
Luke Walling
Messages: 27 Registered: July 2017
Karma: 0
|
Junior Member |
|
|
Hi All,
I got the Onan running good today on a external fuel source.
After blowing out the line with light pressure and the fuel cap removed, I replace the broken clear plastic line, vacuumed up a little fuel, and hooked the coach fuel lines back up.
The amount of fuel I was able to pull was a bit light. I pushed a little fuel back through it with light air pressure and pulled it back down. Helped a little.
But, after the onan empties the pump and carb bowl it spits and sputters-can’t pull enough gas to keep running. It runs fine without the pump and friction fed fuel from above, and with the pump sucking fuel from a gas can.
Fuel lines look good underneath, don’t look that old. The back fuel tank looks to be leaking a fair bit, I can’t tell from where. Top drivers side corner is wet on the bottom.
Any tips from the brain trust for the next day I fiddle with the coach on the fueling the onan front?
Luke
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
|
|
|
Re: [GMCnet] Onan, tracking fuel problems [message #325017 is a reply to message #325015] |
Mon, 16 October 2017 19:02 |
Jim Miller
Messages: 501 Registered: March 2008
Karma: 10
|
Senior Member |
|
|
On Oct 16, 2017, at 7:01 PM, Luke Walling wrote:
> Fuel lines look good underneath, don’t look that old. The back fuel tank looks to be leaking a fair bit, I can’t tell from where. Top drivers side corner is wet on the bottom.
The GMCnet is replete with owners’ accounts of fuel draw problems due to spongy hoses that have deteriorated due to ethanol in our “modern” fuel. Unless you physically examine the lines and can read something like “30R14” or “Gates Barricade” on them then you should assume they are the old formulation that is attacked by ethanol. A classic symptom is the inability to draw sufficient fuel through them to run the {main engine,onan}. My guess is that you have spongy hoses that are weeping and that is the source of the raw fuel you see in and around the tanks.
I do not know what “friction fed” fuel is - but whatever it is it probably isn’t relevant to this particular problem.
—Jim
Jim Miller
1977 Eleganza
1977 Royale
Hamilton, OH
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
Jim Miller
1977 Eleganza II
1977 Royale
Hamilton, OH
|
|
|
|
Re: [GMCnet] Onan, tracking fuel problems [message #325023 is a reply to message #325015] |
Mon, 16 October 2017 21:02 |
Ken Henderson
Messages: 8726 Registered: March 2004 Location: Americus, GA
Karma: 9
|
Senior Member |
|
|
Luke,
As Jim Miller sort of implied, if you're fooling with the Onan and other
accessories before dropping the fuel tanks and replacing ALL of the vent
and supply hoses with modern, ethanol-resistant, hoses (and/or PolyArmor
tubing), you're wasting your time. You'll never have a reliable coach
until that task is completed. Sorry.
Ken H.
Americus, GA
'76 X-Birchaven w/Cad500/Howell EFI & EBL,
Manny Brakes & 1-Ton, Troy-Bilt APU, etc., etc., etc.
www.gmcwipersetc.com
On Mon, Oct 16, 2017 at 7:01 PM, Luke Walling
wrote:
> Hi All,
>
> I got the Onan running good today on a external fuel source.
>
> After blowing out the line with light pressure and the fuel cap removed, I
> replace the broken clear plastic line, vacuumed up a little fuel, and
> hooked the coach fuel lines back up.
>
> The amount of fuel I was able to pull was a bit light. I pushed a little
> fuel back through it with light air pressure and pulled it back down.
> Helped a little.
>
> But, after the onan empties the pump and carb bowl it spits and
> sputters-can’t pull enough gas to keep running. It runs fine without the
> pump and friction fed fuel from above, and with the pump sucking fuel from
> a gas can.
>
> Fuel lines look good underneath, don’t look that old. The back fuel tank
> looks to be leaking a fair bit, I can’t tell from where. Top drivers side
> corner is wet on the bottom.
>
> Any tips from the brain trust for the next day I fiddle with the coach on
> the fueling the onan front?
>
> Luke
>
> _______________________________________________
> GMCnet mailing list
> Unsubscribe or Change List Options:
> http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
>
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
Ken Henderson
Americus, GA
www.gmcwipersetc.com
Large Wiring Diagrams
76 X-Birchaven
76 X-Palm Beach
|
|
|
Re: [GMCnet] Onan, tracking fuel problems [message #325024 is a reply to message #325023] |
Mon, 16 October 2017 21:16 |
Luke Walling
Messages: 27 Registered: July 2017
Karma: 0
|
Junior Member |
|
|
Given the expense of the roof AC and Generator if they needed to be replaced, it was important for me to make sure these things worked properly before going deeper.
Now.. I shall!
On Mon, Oct 16, 2017 at 10:03 PM -0400, "Ken Henderson" wrote:
Luke,
As Jim Miller sort of implied, if you're fooling with the Onan and other
accessories before dropping the fuel tanks and replacing ALL of the vent
and supply hoses with modern, ethanol-resistant, hoses (and/or PolyArmor
tubing), you're wasting your time. You'll never have a reliable coach
until that task is completed. Sorry.
Ken H.
Americus, GA
'76 X-Birchaven w/Cad500/Howell EFI & EBL,
Manny Brakes & 1-Ton, Troy-Bilt APU, etc., etc., etc.
www.gmcwipersetc.com
On Mon, Oct 16, 2017 at 7:01 PM, Luke Walling
wrote:
> Hi All,
>
> I got the Onan running good today on a external fuel source.
>
> After blowing out the line with light pressure and the fuel cap removed, I
> replace the broken clear plastic line, vacuumed up a little fuel, and
> hooked the coach fuel lines back up.
>
> The amount of fuel I was able to pull was a bit light. I pushed a little
> fuel back through it with light air pressure and pulled it back down.
> Helped a little.
>
> But, after the onan empties the pump and carb bowl it spits and
> sputters-can’t pull enough gas to keep running. It runs fine without the
> pump and friction fed fuel from above, and with the pump sucking fuel from
> a gas can.
>
> Fuel lines look good underneath, don’t look that old. The back fuel tank
> looks to be leaking a fair bit, I can’t tell from where. Top drivers side
> corner is wet on the bottom.
>
> Any tips from the brain trust for the next day I fiddle with the coach on
> the fueling the onan front?
>
> Luke
>
> _______________________________________________
> GMCnet mailing list
> Unsubscribe or Change List Options:
> http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
>
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
_______________________________________________
GMCnet mailing list
Unsubscribe or Change List Options:
http://list.gmcnet.org/mailman/listinfo/gmclist_list.gmcnet.org
|
|
|
Goto Forum:
Current Time: Wed Apr 24 00:09:44 CDT 2024
Total time taken to generate the page: 0.01002 seconds
|